Product ID:CPS241070 CHEVRON UNDERCOATING AF
MSDS Date:05/29/1991
FSC:8010
NIIN:00F036285
MSDS Number: BTVQG

CHEVRON ENVIRONMENTAL HEALTH CENTER INC

15299 SAN PABLO AVE
RICHMOND, CA 94804
US

Emergency Phone: 510-233-3737/457-2022

Info Phone: 415-233-3737/510-242-2736

Cage: 0AHD1

CHEVRON ENVIRONMENTAL HEALTH CENTER INC

4054 RICHMOND, CA 94804 US

Telephone: 800-582-3835

Cage: 0AHD1

ASPHALT FUMES, ASPHALT, CUTBACK ASPHALT

CAS: 8052-42-4

RTECS: CI9900000

Fraction By Weight: >48%

ACGIH TLV: 5 MG/CUM

STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: <50%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

ADDITIVES

Fraction By Weight: <2%

435 GM/LITER OF COATING.

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: SLIGHTLY IRRITATING, COULD CAUSE
PROLONGED VISION IMPAIRMENT. SKIN: MODERATE IRRITANT. INHALATION:
PROLONGED BREATHING OF VAPORS CAN CAUSE CNS EFFECTS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, PAIN, TEARS, SWELLING, REDNESS,
BLURRED VISION, FEELING OF HEAT, DISCOLORATION, BLISTERING,
HEADACHE, DIZZINESS, LOSS OF APPETITE, WEAKNESS, LOSS OF
COORDINATION

First Aid:EYES: FLUSH IMMEDIATELY W/FRESH WATER FOR 15 MINS. REMOVE
CONTACT LENSES IF WORN. SKIN: WASH W/SOAP & WATER. DON'T USE
SOLVENTS/THINNERS TO REMOVE MATERIALS FROM SKIN. ASPHALT CAN BE
REMOVED W/VEGETAB LE OIL/MINERAL OIL. INHALATION: MOVE TOFRESH AIR.
INGESTION: GIVE WATER/MILK TO DRINK. DON'T MAKE PERSON VOMIT UNLESS
DIRECTED BY MEDICAL PERSONNEL. OBTAIN MEDICAL ATTENTION IN ALL
CASES.

Flash Point Method:PMCC
Flash Point:105F
Lower Limits:1.1 SOLVENT
Upper Limits:6.1 SOLVENT
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG, SAND/EARTH
Fire Fighting Procedures:EXPOSED MATERIAL MAY BE COOLED W/WATER. AVOID
BREATHING SMOKE/MISTS. AVOID PERSONNEL & EQUIPMENT CONTACT
W/FALLOUT & RUNOFF. (SEE SUPP)
Unusual Fire/Explosion Hazard:LIQUID EVAPORATES, FORMS VAPOR FUMES
WHICH CAN CATCH FIRE/BURN W/EXPLOSIVE VIOLENCE. VAPORS SPREAD, ACT
ON FIRE BY IGNITION SOURCES. LIQUID TEMP >85F, A HAZARD.

Spill Release Procedures:ELIMINATE OPEN FLAME/RELEASED VAPOR. STOP
SOURCE OF LEAK/RELEASE. CLEAN UP AS SOON AS POSSIBLE. CONTAIN
LIQUID TO PREVENT CONTAMINATION OF SOIL, SURFACE WATER/GROUNDWATER.
SMALL: CLEAN UP USING SORBEN T MATERIALS/PUMPING. REMOVE
CONTAMINATED SOIL.

Handling and Storage Precautions:DON'T USE/STORE NEAR FLAME, SPARKS/HOT
SURFACES. USE ONLY IN WELL VENTILATED AREA. KEEP CONTAINER CLOSED.
DON'T WELD, HEAT/DRILL CONTAINER.
Other Precautions:REPLACE CAP/BUNG. EMPTIED CONTAINER STILL CONTAINS
HAZARDOUS/EXPLOSIVE VAPOR/LIQUID. DON'T USE PRESSURE TO EMPTY
DRUM/EXPLOSION MAY RESULT. DON'T ATTEMPT RESCUE W/O WEARING
APPROVED SUPPLIED AIR/SELF CONTAINED BREATHING EQUIPMENT.

Respiratory Protection:IF OPERATING CONDITIONS CREATE HIGH
VAPOR/ASPHALT FUME CONCENTRATIONS, THE USE OF AN APPROVED
RESPIRATOR IS RECOMMENDED TO LIMIT EXPOSURE.
Ventilation:WELL VENTILATED REQUIRED
Protective Gloves:REQUIRED
Eye Protection:CHEMICAL GOGGLES
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. DISCARD CONTAMINATED NON-WATERPROOF SHOES/BOOTS.
Supplemental Safety and Health
EVAPORATION RATE CONT'D: SOLVENT PORTION. VAPOR PRESSURE & VAPOR
DENSITY (SOLVENT). SPEC FIRE PROC CONT'D: MINIMIZE THE AMOUNT OF
WATER USED FOR FIRE FIGHTING. DON'T ENTER ANY ENCLOSED AREA W/O
FULL P ROTECTIVE & SELF CONTAINED EQUIPMENT. CONTAIN & ISOLATE
RUNOFF & DEBRIS FOR PROPER DISPOSAL.

Boiling Pt:B.P. Text:316F (SUPP)
Vapor Pres:3 (SUPP)
Vapor Density:4.9 (SUPP)
Spec Gravity:.9
Evaporation Rate & Reference:(BU AC=1): 0.21(SEE SUPP)
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK SEMI-SOLID ASPHALT W/AN ODOR SIMILAR TO PAINT
THINNER
Percent Volatiles by Volume:55

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, CHLORATE, NITRATES, PEROXIDES

Waste Disposal Methods:PLACE CONTAMINATED MATERIALS IN DISPOSABLE
CONTAINERS IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.